Dodge 2008 Charger Wartungshandbuch

2008 Dodge Charger/Magnum Police Upfitter's Guide Table of Contents INTRODUCTION1 GENERAL INFORMATION3AIRBAGS4INSTALLATION CONSIDERATIONS2

1 - 8 GENERAL INFORMATION 2008 Police Upfitter’s GuideBODY CODE PLATELOCATIONThe body code plate is located in the engine compartmenton the front right

2008PoliceUpfitter’s Guide GENERAL INFORMATION 1 - 9Digit 19Open spaceDigits 20, 21, and 22 Engine code• EGG = 3.5 L, V-6 Cylinder, 24 Valve, High Outp

1 - 10 GENERAL INFORMATION 2008 Police Upfitter’s GuideMANUFACTURER PLATEThe manufacturer plate is located in the engine compart-ment on the passenger

2008PoliceUpfitter’s Guide 2-1ELECTRICALTABLE OF CONTENTSPage PageELECTRICAL BASICS . . . . . . . . . . . . . . . 1ALTERNATOROUTPUT... 1VEHI

2 - 2 ELECTRICAL 2008 Police Upfitter’s GuideAlternator OutputCondition Engine SpeedAlternator TemperatureOutput CurrentIdle 624 RPM93°C (200°F)90APARK

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 3INSTALLING ADDITIONAL ELECTRICAL EQUIPMENTPrior to determining what equipment is to be installed into the po

2 - 4 ELECTRICAL 2008 Police Upfitter’s GuideNOTE: A police accessories mating connector is avail-able in the MOPAR® kit P/N 05191127AB.The police acce

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 5POLICE FUSE/RELAY BLOCKThe police accessories connector circuits are fed by 3fuses and 3 fused relays locate

2 - 6 ELECTRICAL 2008 Police Upfitter’s GuidePOWER DISTRIBUTION CENTER (PDC) STUDIf a power source is required in the trunk, a connection can be made a

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 7The police/taxi interface connector is located under the in-strument panel center stack area and can be acce

2008PoliceUpfitter’s Guide 0-1INTRODUCTIONTABLE OF CONTENTSPageINTRODUCTION... 1 INTRODUCTIONThePoliceUpfitter’s Guide has been prepared

2 - 8 ELECTRICAL 2008 Police Upfitter’s Guide10W518 20BR/DGFront airbag status signal 12V, 20mA voltage signal11W530 20BR/DG PTIM CAN B bus (+) CAN B12

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 9NOTE: A police radio mating connector is available inthe MOPAR® kit P/N 05191127AB.The connector is a 3–way

2-10 ELECTRICAL 2008 Police Upfitter’s GuideThe 12–way (police accessories) connector is located atthe bottom of center stack of the instrument panel.

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 11The police dome lamp is a 2–way (BLACK) connector, andis wired as follows:Police Dome Lamp ConnectorCavity

2-12 ELECTRICAL 2008 Police Upfitter’s GuideSTEALTH MODESTEALTH MODE SWITCHIn stealth mode all of the police vehicle interior lights including the inst

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 13BODY HARNESS – CENTER TUNNEL AREA1. Body harness2. Dynamics electronic stability program (ESP) sensor3. Occ

2-14 ELECTRICAL 2008 Police Upfitter’s GuideBODY HARNESS – LEFT REAR FLOOR AREABODY HARNESS – RIGHT FRONT FLOOR AREA1. Body harness2. Battery B+ cable3

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 15BODY HARNESS – RIGHT REAR FLOOR AREA1. Battery B+ cable2. Body harnessBODY HARNESS – TRUNK/CARGO AREA1. Bat

2-16 ELECTRICAL 2008 Police Upfitter’s GuideHEADLINER HARNESSWIRING DIAGRAMSThe following pages represent the police vehicle specific wiring diagrams in

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 17POWERDISTRIBUTIONCENTER–1OF4

2008PoliceUpfitter’s Guide 1-1GENERAL INFORMATIONTABLE OF CONTENTSPage PageDISCLAIMER... 1CAUTIONSANDWARNINGS... 1VEHICLEMODIF

2-18 ELECTRICAL 2008 Police Upfitter’s GuidePOWERDISTRIBUTIONCENTER–2OF4

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 19POWERDISTRIBUTIONCENTER–3OF4

2-20 ELECTRICAL 2008 Police Upfitter’s GuidePOWERDISTRIBUTIONCENTER–4OF4

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 21POLICE FUSE/RELAY BLOCK – 1 OF 2

2-22 ELECTRICAL 2008 Police Upfitter’s GuidePOLICE FUSE/RELAY BLOCK – 2 OF 2

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 23POWER DISTRIBUTION SCHEMATICS – 1 OF 2

2-24 ELECTRICAL 2008 Police Upfitter’s GuidePOWER DISTRIBUTION SCHEMATICS – 2 OF 2

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 25POLICE VEHICLE COMMUNICATION SCHEMATICS – 1 OF 2

2-26 ELECTRICAL 2008 Police Upfitter’s GuidePOLICE VEHICLE COMMUNICATION SCHEMATICS – 2 OF 2

2008PoliceUpfitter’s Guide ELECTRICAL 2 - 27POLICE VEHICLE INTERIOR/EXTERIOR LIGHTING SCHEMATICS

1 - 2 GENERAL INFORMATION 2008 Police Upfitter’s GuideWARNING: AFTER INSTALLING ANY EQUIPMENT OR AFTER ANY OTHER WORK IS COMPLETED, TURN THEIGNITION KE

2-28 ELECTRICAL 2008 Police Upfitter’s GuidePOLICE RADIO AND SUPPLEMENTAL EQUIPMENT WIRING SCHEMATICS

2008PoliceUpfitter’s Guide 3-1AIRBAGSTABLE OF CONTENTSPage PageOCCUPANT RESTRAINT SYSTEM. . . . . . . . 1PASSENGER COMPARTMENT . . . . . . . . . . 7FRO

3 - 2 AIRBAGS 2008 Police Upfitter’s Guide•Occupant restraint controller (ORC) module• Driver seat belt tensioner• Passenger seat belt tensioner• Left

2008PoliceUpfitter’s Guide AIRBAGS 3 - 3NOTE: Illustration represents the final deploymentshape.DRIVER AIRBAG/STEERING COLUMN SPECIFICATIONSDriver Airba

3 - 4 AIRBAGS 2008 Police Upfitter’s GuidePASSENGER AIRBAG DEPLOYMENT ZONENOTE: Illustration represents the maximum dynamicdeployment shape.The passeng

2008PoliceUpfitter’s Guide AIRBAGS 3 - 5The passenger airbag lateral deployment zone is identi-fied as follows:1. 71 mm (2.8 in.)2. Passenger airbag cus

3 - 6 AIRBAGS 2008 Police Upfitter’s GuideSIDE AIRBAG DEPLOYMENT ZONENOTE: Illustration represents the final deployment shape.The side airbag deployment

2008PoliceUpfitter’s Guide AIRBAGS 3 - 74. 401.3 mm (15.8 in.)5. 970.3 mm (38.2 in.)6. 559.0 mm (22.0 in.)7. 91.4 mm (3.6 in.)8. 310.0 mm (12.2 in.)9.

3 - 8 AIRBAGS 2008 Police Upfitter’s GuideNOTE: Right side curtain airbag shown, left side sim-ilar.SIDE CURTAIN AIRBAG – FRONT ROOF AREANOTE: Right si

2008PoliceUpfitter’s Guide AIRBAGS 3 - 9NOTE: Right side curtain airbag shown, left side sim-ilar.SIDE CURTAIN AIRBAG – REAR ROOF AREANOTE: Right side

2008PoliceUpfitter’s Guide GENERAL INFORMATION 1 - 3SAFETY DEVICESThe Dodge Charger and Magnum are factory equipped with many safety devices and featur

3 - 10 AIRBAGS 2008 Police Upfitter’s GuideNOTE: Right side curtain airbag shown, left side sim-ilar.SIDE CURTAIN AIRBAG – C AND D-PILLARAREA (MAGNUM)S

2008PoliceUpfitter’s Guide AIRBAGS 3 - 11NOTE: Right side C-pillar impact sensor shown, leftside similar.An impact sensor is mounted on the inside at t

3 - 12 AIRBAGS 2008 Police Upfitter’s GuideSEATSCAUTION: When installing additional equipment around the front seats, consider the following restrictio

2008PoliceUpfitter’s Guide 4-1INSTALLATION CONSIDERATIONSTABLE OF CONTENTSPage PageGENERALGUIDELINES... 1PASSENGER COMPARTMENT . . . . . . .

4 - 2 INSTALLATION CONSIDERATIONS 2008PoliceUpfitter’s GuideThe police equipment mounting bracket has the followingdimensions:• A = 42.77 mm (1.7 in.)•

2008PoliceUpfitter’s Guide INSTALLATION CONSIDERATIONS 4 - 3ROOF MOUNTED EQUIPMENTIf the vehicle is equipped with side curtain airbags, take care when

4 - 4 INSTALLATION CONSIDERATIONS 2008PoliceUpfitter’s GuideNOTE: Right side curtain airbag shown, left side sim-ilar.SIDE CURTAIN AIRBAG – REAR ROOF A

2008PoliceUpfitter’s Guide INSTALLATION CONSIDERATIONS 4 - 5NOTE: Right side curtain airbag shown, left side sim-ilar.SIDE CURTAIN AIRBAG – C AND D-PIL

4 - 6 INSTALLATION CONSIDERATIONS 2008PoliceUpfitter’s GuideNOTE: Right side C-pillar impact sensor shown, leftside similar.An impact sensor is mounted

2008PoliceUpfitter’s Guide INSTALLATION CONSIDERATIONS 4 - 7SEATSWARNING: IF EQUIPPED WITH OCCUPANT CLASSIFICATION SYSTEM (OCS), THE SEAT WEIGHT SENSOR

1 - 4 GENERAL INFORMATION 2008 Police Upfitter’s GuideThe DodgeMagnum vehicles have the following overall exterior dimensions:• Length (A) = 5,021 mm (

4 - 8 INSTALLATION CONSIDERATIONS 2008PoliceUpfitter’s GuideCARGO/TRUNK AREABATTERY COVERIfthevehicleisequippedwithafullsizesparetire,thebattery has an

2008PoliceUpfitter’s Guide INSTALLATION CONSIDERATIONS 4 - 9VEHICLE UNDERBODYBELLY PANSThe Dodge Charger and Magnum are equipped with 6 underbody shiel

4 - 10 INSTALLATION CONSIDERATIONS 2008PoliceUpfitter’s GuideFRONT IMPACT SENSORSNOTE: Right front impact sensor shown, left front im-pact sensor simil

2008PoliceUpfitter’s Guide GENERAL INFORMATION 1 - 5VEHICLE IDENTIFICATIONVEHICLE IDENTIFICATION NUMBER (VIN)The VIN plate is attached to the body, and

1 - 6 GENERAL INFORMATION 2008 Police Upfitter’s GuidePOSITION INTERPRETATION CODE = DESCRIPTIONH = Restraint System Air bags FrontNext Generation Mult

2008PoliceUpfitter’s Guide GENERAL INFORMATION 1 - 7VEHICLE EMISSION CONTROL INFORMATION (VECI) LABELAll vehicles are equipped with a combined VECI lab