Dodge RAM 1500 2010 Bedienungshandbuch PDF herunterladen

3651 N. Hwy 89 • Chino Valley, AZ 86323

(928) 636-3175 • www.p-a-g.net

DODGE RAM 1500 4WD

2” FRONT & 1.5” REAR

COIL SPRING LIFT KIT

INSTALLATION INSTRUCTIONS

2009 - 2010 KIT# DL229

WARNING

Installation of a Performance Automotive Group sus-

pension lift kit will change the vehicle’s center of gravity

and handling characteristics both on- and off-road. You

must drive the vehicle safely! Extreme care must be

taken to prevent vehicle rollover or loss of control,

which could result in serious injury or death. Avoid sud-

den sharp turns or abrupt maneuvers and always make

sure all vehicle occupants have their seat belts fas-

tened.

WARNING

Before you install this kit, read and understand all

instructions, warnings, cautions, and notes in this

instruction sheet and in the vehicle owner’s manual.

CAUTION

Proper installation of this kit requires knowledge of the

factory recommended procedures for removal and

installation of original equipment components. We rec-

ommend that the factory shop manual and any special

tools needed to service your vehicle be on hand during

the installation. Installation of this kit without proper

knowledge of the factory recommended procedures

may affect the performance of these components and

the safety of the vehicle. We strongly recommend that

a certified mechanic familiar with the installation of sim-

ilar components install this kit.

WARNING

This kit should only be installed on a vehicle that is in

good working condition. Before you install the kit, thor-

oughly inspect the vehicle for corrosion or deformation

of the sheet metal. If the vehicle is suspected to have

been in a collision or misused, do not install this kit.

Off-road use of your vehicle with this kit installed may

increase the stress applied to the factory components.

Failure to observe this warning may result in serious

personal injury and/or severe damage to your vehicle.

WARNING

Many states and municipalities have laws restricting

bumper heights and vehicle lifts. Consult state and

local laws to determine if the changes you intend to

make to the vehicle comply with the law.

WARNING

The installation of larger tires may reduce the effective-

ness of the braking system.

WARNING

Always wear eye protection when operating power

tools.

WARNING

Before you install this kit, block the vehicle tires to pre-

vent the vehicle from rolling.

WARNING

DO NOT combine suspension, body, or other lift

devices. Use of vehicle with combined lifts may result

in unsafe and/or unexpected handling characteristics.

NOTE

Lift height may vary depending on vehicle configura-

tion, engine size, additional accessories, the factory

suspension package, and vehicle’s condition.

1 ‘09-’10 1500 Front Leveling - Kit DL229

1 2 3 4 5 6 7 8 9

Inhaltsverzeichnis

Seite 1 - 2009 - 2010 KIT# DL229

3651 N. Hwy 89 • Chino Valley, AZ 86323(928) 636-3175 • www.p-a-g.netDODGE RAM 1500 4WD2” FRONT & 1.5” REARCOIL SPRING LIFT KITINSTALLATION INSTRU

Seite 2 - Before Starting Installation

2 ‘09-’10 1500 Front Leveling - Kit DL229Before Starting Installation1. Carefully read all warnings and instructions com-pletely before beginning.2. V

Seite 3 - Prepare to Install Front Kit

3 ‘09-’10 1500 Front Leveling - Kit DL229Engine Compartment1. Disconnect both battery cables. Disconnect negativecable first, then positive cable.Prep

Seite 4 - Install Front Coil Spacer Kit

4 ‘09-’10 1500 Front Leveling - Kit DL229b. Remove nut and upper A-arm from steeringknuckle.c. Remove nut and bolt from coil-over assemblyand lower A-

Seite 5

5 ‘09-’10 1500 Front Leveling - Kit DL229d. Uncompress coil spring and remove upper plateand isolator from ramp and coil spring.e. Install kit spacer

Seite 6

6 ‘09-’10 1500 Front Leveling - Kit DL2292. Driver coil-over assemblya. Install coil-over assembly onto upper perch withthree nuts. DO NOT TIGHTEN.b.

Seite 7 - Prepare to Install Rear Kit

7 ‘09-’10 1500 Front Leveling - Kit DL229Prepare to Install Rear Kit1. Loosen, but do not remove, lug nuts on each rearwheel.2. Using a hydraulic floo

Seite 8 - After Completing Installation

8 ‘09-’10 1500 Front Leveling - Kit DL229much greater now that the kit coil spacer is inplace.) 3. Install ABS lines back into there clips.4. instal

Seite 9 - Kit Parts List

9 ‘09-’10 1500 Front Leveling - Kit DL229Kit Parts ListQty. Description2 - Front Coil Spacers2 - Rear Coil Spacers CAUTIONPerformance Automotive G